Clutch Problems 2003 Tiburon
 

Posting for my daughter so the car may be a 2004 instead of 03. Anyway, she
has started to experience clutch problems with her Tiburon (20,000 miles).
Sounds like possilby the clutch plate or disc is warped. Push the clutch in
and the transmission will not disengage. Hard to shift into low. Took
into dealer and he could not get it to act up (always the way). We drained
and refilled the fluid in case that might be the problem. No help. Before
anyone blames poor clutch techniques, my daughter's first car was a stick
and she put over 100,000 miles on her Honda Del Sol (also a standard shift)
without any clutch or transmisson problems.

ny one else experiencing anything similar with their stick-shifts?

Thanks

Re: Clutch Problems 2003 Tiburon
 

SuperGlide wrote:
> Posting for my daughter so the car may be a 2004 instead of 03. Anyway, she
> has started to experience clutch problems with her Tiburon (20,000 miles).
> Sounds like possilby the clutch plate or disc is warped. Push the clutch in
> and the transmission will not disengage. Hard to shift into low. Took
> into dealer and he could not get it to act up (always the way). We drained
> and refilled the fluid in case that might be the problem. No help. Before
> anyone blames poor clutch techniques, my daughter's first car was a stick
> and she put over 100,000 miles on her Honda Del Sol (also a standard shift)
> without any clutch or transmisson problems.
>
> ny one else experiencing anything similar with their stick-shifts?
>
> Thanks
>
>
Could be something in the mechanism is loosening which is causing the
adjustment change.

Another thing to consider is the floor mats. If the mat gets under the
petal and prevents it from going all the way down it could cause
problems. A simple thing that sometimes can cause intermittent problems.

Good Luck,


-=-=-
.... Just because it's impossible is no reason not to do it.

Re: Clutch Problems 2003 Tiburon
 

On Sat, 21 May 2005 19:27:53 -0500, Edd staggered into the Black Sun and
said:
> SuperGlide wrote:
>> Posting for my daughter so the car may be a 2004 instead of 03.
>> Anyway, she has started to experience clutch problems with her
>> Tiburon (20,000 miles).

Is this a V6 or I4 engine? ISTR hearing that for the 2003 V6 Tiburons,
they used the same clutch as they did in the 4-banger models. The extra
power of the engine apparently caused premature clutch wear in a lot of
cases. The fix suggested by the folks at http://newtiburon.com/ was
"install an aftermarket racing clutch", which apparently helped a lot.
If this is a 4-banger, then that's probably not the problem.

>> Took into dealer and he could not get it to act up (always the way).

It always works in your office; it always fails in the Boss's office.

>> We drained and refilled the fluid in case that might be the problem.
>> No help. Before anyone blames poor clutch techniques, my daughter's
> Another thing to consider is the floor mats. If the mat gets under

I don't think this is likely on a 2003 Tiburon. The mats have eyelets
in them which fit into hooks in the car's floor, and those keep the mat
in approximately the right place. Oh well, check it anyway; it won't
take too long.

--
Matt G|There is no Darkness in eternity/But only Light too dim for us to see
"We should have a policy against using personal resources for company
business." "The Company didn't pay for these pants, so I'm taking them
off at the door!" --J. Moore and A. DeBoer, the Monastery

Re: Clutch Problems 2003 Tiburon
 

"Dances With Crows" <danSPANceswitTRAPhcrows@gmail.com> wrote in message
news:slrnd8vmvr.qb1.danSPANceswitTRAPhcrows@samant ha.crow202.dyndns.org...
> On Sat, 21 May 2005 19:27:53 -0500, Edd staggered into the Black Sun and
> said:
>> SuperGlide wrote:
>>> Posting for my daughter so the car may be a 2004 instead of 03.
>>> Anyway, she has started to experience clutch problems with her
>>> Tiburon (20,000 miles).
>
> Is this a V6 or I4 engine? ISTR hearing that for the 2003 V6 Tiburons,
> they used the same clutch as they did in the 4-banger models. The extra
> power of the engine apparently caused premature clutch wear in a lot of
> cases. The fix suggested by the folks at http://newtiburon.com/ was
> "install an aftermarket racing clutch", which apparently helped a lot.
> If this is a 4-banger, then that's probably not the problem.
>

Thanks. Really hope you are wrong though about needing a clutch upgrade.

SuperGlide

Re: Clutch Problems 2003 Tiburon
 

had to have the clutch replace in my 04 Elantra GT.. had a bent throughout
bearing so they replaced the whole clutch assembly, under warranty....


Pete...

"SuperGlide" <SuperGlide@nosight.com> wrote in message
news:E%Oje.11591$V2.9863@attbi_s72...
> Posting for my daughter so the car may be a 2004 instead of 03. Anyway,
> she has started to experience clutch problems with her Tiburon (20,000
> miles). Sounds like possilby the clutch plate or disc is warped. Push the
> clutch in and the transmission will not disengage. Hard to shift into
> low. Took into dealer and he could not get it to act up (always the
> way). We drained and refilled the fluid in case that might be the
> problem. No help. Before anyone blames poor clutch techniques, my
> daughter's first car was a stick and she put over 100,000 miles on her
> Honda Del Sol (also a standard shift) without any clutch or transmisson
> problems.
>
> ny one else experiencing anything similar with their stick-shifts?
>
> Thanks
>

Re: Clutch Problems 2003 Tiburon
 

"Pete" <range1@shaw.ca> wrote in message
news:V6Vje.1434834$6l.1273950@pd7tw2no...
> had to have the clutch replace in my 04 Elantra GT.. had a bent throughout
> bearing so they replaced the whole clutch assembly, under warranty....

Thanks, Pete. Hope we are as lucky (if have problem similar to yours).

SuperGlide

Re: Clutch Problems 2003 Tiburon
 

our accent will not let you go into 1st gear if your going over a certain
speed, is that the case or will it not let it even when its sitting still?
"SuperGlide" <SuperGlide@nosight.com> wrote in message
news:E%Oje.11591$V2.9863@attbi_s72...
> Posting for my daughter so the car may be a 2004 instead of 03. Anyway,
> she has started to experience clutch problems with her Tiburon (20,000
> miles). Sounds like possilby the clutch plate or disc is warped. Push the
> clutch in and the transmission will not disengage. Hard to shift into
> low. Took into dealer and he could not get it to act up (always the
> way). We drained and refilled the fluid in case that might be the
> problem. No help. Before anyone blames poor clutch techniques, my
> daughter's first car was a stick and she put over 100,000 miles on her
> Honda Del Sol (also a standard shift) without any clutch or transmisson
> problems.
>
> ny one else experiencing anything similar with their stick-shifts?
>
> Thanks
>

Re: Clutch Problems 2003 Tiburon
 

"Jody" <jaaribare@yahoo.com> wrote in message
news:3Bpke.2414$Ot6.393495@news20.bellglobal.com.. .
> our accent will not let you go into 1st gear if your going over a certain
> speed, is that the case or will it not let it even when its sitting
> still?

Transmission does not want to disengage when pushing the clutch in. Wants to
continue pulling even when coming to a stop (not always, but too often for
comfort).

SuperGlide

Re: Clutch Problems 2003 Tiburon
 

Thanks to everyone who responded to my earlier post. Visited the daughter
over the weekend and spent a little while under the dash working on the
clutch adjustment. The tech page in the Hyundai web site seems to give some
erroneous information regarding the clutch pedal adjustment. Just no way
(in my opinion) of adjusting the clutch pedal height as much as they
recommend. Maybe the hyundaitech can shed some light on that.

But, while I was down there breaking my back and scraping my arms under the
dash, I noticed the two pistion electrical-switches seemed to limit the
travel and I was able to adjust them to free up a little pedal play. Also,
I noticed that the pedal had been "bottoming out," on the floor mat.
Someone had suggested looking at that. THANKS!! Whatever I did seemed to
correct the problem (at least I could not get it to "happen.") Drove the
Tib for over two hours on Chicago area expressways and suburban highways.

SuperGlide

Re: Clutch Problems 2003 Tiburon
 

i bought my tiburon a little bit over a year ago, used, but in very good
condition, its a 2003 but not the V6, and i started noticing the clutch
slipping out of gears about 2 months ago. i brought it to the hyundai
parts and services place nearby, they charged me $180 to perform a
diagnostic(my warranty is still good), and they came back with the
diagnosis that my clutch needed to be replaced and possibly my flywheel,
however, they told me that it wouldnt be covered under warranty because it
was 'wear n tear'. so i brought it to a guy i know and trust and he went
to fix it. when he was doing so he called me to inform me that it wasnt
due to wear and tear because it was saturated in oil that was leaking from
the transmission. at this point my car was literally undrivebale so i had
him finish replacing the clutch, figuring that i'd bring it back to
hyundai and get my trani fixed and my clutch replacement reinbursed. they
informed me that they werent going to do either because i had gotten it
fixed somewhere else. this isnt right because my clutch cost me $1,000,
and now my transmission is going to cost me between 2-3 thousand, and dont
forget the useless, inaccurate, diagnostic which was 180.
-Helene

Re: Clutch Problems 2003 Tiburon
 

i bought my tiburon a little bit over a year ago, used, but in very good
condition, its a 2003 but not the V6, and i started noticing the clutch
slipping out of gears about 2 months ago. i brought it to the hyundai
parts and services place nearby, they charged me $180 to perform a
diagnostic(my warranty is still good), and they came back with the
diagnosis that my clutch needed to be replaced and possibly my flywheel,
however, they told me that it wouldnt be covered under warranty because it
was 'wear n tear'. so i brought it to a guy i know and trust and he went
to fix it. when he was doing so he called me to inform me that it wasnt
due to wear and tear because it was saturated in oil that was leaking from
the transmission. at this point my car was literally undrivebale so i had
him finish replacing the clutch, figuring that i'd bring it back to
hyundai and get my trani fixed and my clutch replacement reinbursed. they
informed me that they werent going to do either because i had gotten it
fixed somewhere else. this isnt right because my clutch cost me $1,000,
and now my transmission is going to cost me between 2-3 thousand, and dont
forget the useless, inaccurate, diagnostic which was 180.
-Helene

Re: Clutch Problems 2003 Tiburon
 

Heres what you do in the future when this occurs:

Have your shop STOP IMMEDIATELY.

Call Hyundai roadside assistance, tell them the situation, tell them you
want the unassembled pile of crap taken to the Hyundai dealer and fixed.
At this point you (firmly) request they replace the clutch since it
was damaged by their covered component failure.

I sure as hell wouldn't take it to dealer you already visited - a $180
diagnostic for a slipping clutch would have lead to an unconscious
service manager (jaw readjustment)

As for this running you thousands... I might want to consider these are
some of the easiest cars in the world to work on, and the 4-cyl parts
are so plentiful that junkyards every day are destroying *good* Hyundai
transmissions because they're simply not in high demand.

car-parts.com puts the price around $500 for a "good" used MT for your car.

JS

helene wrote:
> i bought my tiburon a little bit over a year ago, used, but in very good
> condition, its a 2003 but not the V6, and i started noticing the clutch
> slipping out of gears about 2 months ago. i brought it to the hyundai
> parts and services place nearby, they charged me $180 to perform a
> diagnostic(my warranty is still good), and they came back with the
> diagnosis that my clutch needed to be replaced and possibly my flywheel,
> however, they told me that it wouldnt be covered under warranty because it
> was 'wear n tear'. so i brought it to a guy i know and trust and he went
> to fix it. when he was doing so he called me to inform me that it wasnt
> due to wear and tear because it was saturated in oil that was leaking from
> the transmission. at this point my car was literally undrivebale so i had
> him finish replacing the clutch, figuring that i'd bring it back to
> hyundai and get my trani fixed and my clutch replacement reinbursed. they
> informed me that they werent going to do either because i had gotten it
> fixed somewhere else. this isnt right because my clutch cost me $1,000,
> and now my transmission is going to cost me between 2-3 thousand, and dont
> forget the useless, inaccurate, diagnostic which was 180.
> -Helene
>

Re: Clutch Problems 2003 Tiburon
 

Heres what you do in the future when this occurs:

Have your shop STOP IMMEDIATELY.

Call Hyundai roadside assistance, tell them the situation, tell them you
want the unassembled pile of crap taken to the Hyundai dealer and fixed.
At this point you (firmly) request they replace the clutch since it
was damaged by their covered component failure.

I sure as hell wouldn't take it to dealer you already visited - a $180
diagnostic for a slipping clutch would have lead to an unconscious
service manager (jaw readjustment)

As for this running you thousands... I might want to consider these are
some of the easiest cars in the world to work on, and the 4-cyl parts
are so plentiful that junkyards every day are destroying *good* Hyundai
transmissions because they're simply not in high demand.

car-parts.com puts the price around $500 for a "good" used MT for your car.

JS

helene wrote:
> i bought my tiburon a little bit over a year ago, used, but in very good
> condition, its a 2003 but not the V6, and i started noticing the clutch
> slipping out of gears about 2 months ago. i brought it to the hyundai
> parts and services place nearby, they charged me $180 to perform a
> diagnostic(my warranty is still good), and they came back with the
> diagnosis that my clutch needed to be replaced and possibly my flywheel,
> however, they told me that it wouldnt be covered under warranty because it
> was 'wear n tear'. so i brought it to a guy i know and trust and he went
> to fix it. when he was doing so he called me to inform me that it wasnt
> due to wear and tear because it was saturated in oil that was leaking from
> the transmission. at this point my car was literally undrivebale so i had
> him finish replacing the clutch, figuring that i'd bring it back to
> hyundai and get my trani fixed and my clutch replacement reinbursed. they
> informed me that they werent going to do either because i had gotten it
> fixed somewhere else. this isnt right because my clutch cost me $1,000,
> and now my transmission is going to cost me between 2-3 thousand, and dont
> forget the useless, inaccurate, diagnostic which was 180.
> -Helene
>

Re: Clutch Problems 2003 Tiburon
 

thank you so much...i just have one more question...i joined onto this
class act law suit thats being filed against hyundai for the clutch and
transmission problems...i need by car in the meantime so i was going to
get it fixed by doing what you had suggested, but is that going to
jeoperadize my chances with the law suit?

Re: Clutch Problems 2003 Tiburon
 

thank you so much...i just have one more question...i joined onto this
class act law suit thats being filed against hyundai for the clutch and
transmission problems...i need by car in the meantime so i was going to
get it fixed by doing what you had suggested, but is that going to
jeoperadize my chances with the law suit?