Follow up to Entourage AC problem
 

Follow-up: I checked and the 7.5 amp (compressor?) fuse was blown - I
didn't replace it as my wife had an appointment with the dealer the
next day. The repair ticket listed low freon as the problem and no
mention of the fuse replacement. Should I be concerned?

Bill

Re: Follow up to Entourage AC problem
 

"Bill" <carver-rem-33@bellsouth.net> wrote in message
news:sk5a55t906fgcsd2agm6ir5u81l3p0ifi1@4ax.com...
> Follow-up: I checked and the 7.5 amp (compressor?) fuse was blown - I
> didn't replace it as my wife had an appointment with the dealer the
> next day. The repair ticket listed low freon as the problem and no
> mention of the fuse replacement. Should I be concerned?
>
> Bill

Does it work? If so, I'd not be overly concerned as it was replaced.

OTOH, did they find and fix the leak? If not, I'd be concerned as leaks
don't generally fix themselves. I've not checked out the Hyundai system,
but most cars have a low pressure switch that will prevent the compressor
from running if low on refrigerant to avoid further damage.

My '91 Buick had a refrigerant leak and the dealer recharged it three times
and could never find the leak. After the last time (it failed a block from
the dealer after a fix) I told him where to look. He said evaporator coils
never leak so they don't test them. I insisted. You can figure the end of
the story It was a $485 fix, under warranty.

Re: Follow up to Entourage AC problem
 

On Jul 8, 6:00 pm, Bill <carver-rem...@bellsouth.net> wrote:
> Follow-up: I checked and the 7.5 amp (compressor?) fuse was blown - I
> didn't replace it as my wife had an appointment with the dealer the
> next day. The repair ticket listed low freon as the problem and no
> mention of the fuse replacement. Should I be concerned?
>
> Bill

Yep. Perhaps make a call to the service manager and ask the following
questions:
-- Why is there no mention of replacing the fuse?
-- Was there any effort to locate the cause of the blown fuse?
(Hint-- it won't be caused by low refrigerant since the system will
turn itself off in this event)
-- Did the effort to locate the cause include a check of the field
coil resistance as specified in TSB 07-97-003?

If you don't have an account at hmaservice.com, register for one. The
TSB doesn't really say much other than the field coil resistance
specification for several newer models. Regardless, it'll help if
you've read it and understand its relevance. Every single vehicle (to
which the TSB applies) I've encountered with the 7.5A A/C fuse blown
needed a field coil. Typical resistance readings for the defective
field coils were around 2 Ohms.