First problem - 2006 Elantra brakes
Guest
Posts: n/a
First problem - 2006 Elantra brakes
For over a year now my Elantra has run flawlessly, started every time.
I've tolerated the 65mph vibration plague, the 21mpg in town, the slow 1-
2 gear shifting automatic, skipping cd's, because it just seems to be a
good basic but cheap car, and I saved several thousand over the Corolla
or Civic I was initially going to buy. Also wound up buying my wife a
'07 Tucson a few months later after I bought mine, for a really good
deal. First Hyundai's.
But now I'm getting concerned about the future. Took it in to the dealer
for it's second oil change and to check a clicking sound that was coming
from the rear brake area. It has 5300 miles on it. After a couple of
hours shopping I went back to check on the car. The service person told
me the rear brakes were worn out, and it would be $287.50 to fix them, as
the 1 year warranty had run out.
After a low-key but very serious discussion of what the heck are brakes
doing wearing out at 5000 miles, would I be doing this every 5000 miles,
is it normal, then management consulted, no situation change. I told them
forget it, put the car back together, and I was going to write Hyundai. I
did get the oil changed though at least.
I've rarely used the emergency brake in the flatland here, it doesn't
seem tight or draggy, and I don't do any drifting as I'm an old fart.
Monday I'm going to take it to a garage nearby and ask them to evaluate
and if cheaper than the dealer, fix the brakes. Any suggestion on what
brand/type of shoes to use that might last longer? Also is it Hyundai of
America I write to, any specific address?
I'm concerned for the future as my previous three Toyotas and Honda's,
all had over 50,000 miles on them(two over 80,000) and I never had to
replace any brakes, only batteries and one repair between the three. I
know I've had a long run of very good luck with virtually no car
problems, and was hoping it would continue with the Hyundai's.
Thanks for any info!
I've tolerated the 65mph vibration plague, the 21mpg in town, the slow 1-
2 gear shifting automatic, skipping cd's, because it just seems to be a
good basic but cheap car, and I saved several thousand over the Corolla
or Civic I was initially going to buy. Also wound up buying my wife a
'07 Tucson a few months later after I bought mine, for a really good
deal. First Hyundai's.
But now I'm getting concerned about the future. Took it in to the dealer
for it's second oil change and to check a clicking sound that was coming
from the rear brake area. It has 5300 miles on it. After a couple of
hours shopping I went back to check on the car. The service person told
me the rear brakes were worn out, and it would be $287.50 to fix them, as
the 1 year warranty had run out.
After a low-key but very serious discussion of what the heck are brakes
doing wearing out at 5000 miles, would I be doing this every 5000 miles,
is it normal, then management consulted, no situation change. I told them
forget it, put the car back together, and I was going to write Hyundai. I
did get the oil changed though at least.
I've rarely used the emergency brake in the flatland here, it doesn't
seem tight or draggy, and I don't do any drifting as I'm an old fart.
Monday I'm going to take it to a garage nearby and ask them to evaluate
and if cheaper than the dealer, fix the brakes. Any suggestion on what
brand/type of shoes to use that might last longer? Also is it Hyundai of
America I write to, any specific address?
I'm concerned for the future as my previous three Toyotas and Honda's,
all had over 50,000 miles on them(two over 80,000) and I never had to
replace any brakes, only batteries and one repair between the three. I
know I've had a long run of very good luck with virtually no car
problems, and was hoping it would continue with the Hyundai's.
Thanks for any info!
Guest
Posts: n/a
Re: First problem - 2006 Elantra brakes
> But now I'm getting concerned about the future. Took it in to the dealer
> for it's second oil change and to check a clicking sound that was coming
> from the rear brake area. It has 5300 miles on it. After a couple of
> hours shopping I went back to check on the car. The service person told
> me the rear brakes were worn out, and it would be $287.50 to fix them, as
> the 1 year warranty had run out.
>
> After a low-key but very serious discussion of what the heck are brakes
> doing wearing out at 5000 miles, would I be doing this every 5000 miles,
> is it normal, then management consulted, no situation change. I told them
> forget it, put the car back together, and I was going to write Hyundai. I
> did get the oil changed though at least.
>
I've got a 2003 Elantra GLS with almost 70k miles on it and I still have not
needed a brake job, so there is definitely something wrong with your
situation. Sounds like you didn't buy the car new ( ? ) Any chance it was
abused before you got it? I'd be interested to know what your local garage
says.
> for it's second oil change and to check a clicking sound that was coming
> from the rear brake area. It has 5300 miles on it. After a couple of
> hours shopping I went back to check on the car. The service person told
> me the rear brakes were worn out, and it would be $287.50 to fix them, as
> the 1 year warranty had run out.
>
> After a low-key but very serious discussion of what the heck are brakes
> doing wearing out at 5000 miles, would I be doing this every 5000 miles,
> is it normal, then management consulted, no situation change. I told them
> forget it, put the car back together, and I was going to write Hyundai. I
> did get the oil changed though at least.
>
I've got a 2003 Elantra GLS with almost 70k miles on it and I still have not
needed a brake job, so there is definitely something wrong with your
situation. Sounds like you didn't buy the car new ( ? ) Any chance it was
abused before you got it? I'd be interested to know what your local garage
says.
Guest
Posts: n/a
Re: First problem - 2006 Elantra brakes
"unkadunk" <unkadunk@nothere.com> wrote in message
news:Xns9A5C5F2F11Eunkadunknotherecom@216.196.97.1 36...
>
> But now I'm getting concerned about the future. Took it in to the dealer
> for it's second oil change and to check a clicking sound that was coming
> from the rear brake area. It has 5300 miles on it. After a couple of
> hours shopping I went back to check on the car. The service person told
> me the rear brakes were worn out, and it would be $287.50 to fix them, as
> the 1 year warranty had run out.
>
> After a low-key but very serious discussion of what the heck are brakes
> doing wearing out at 5000 miles, would I be doing this every 5000 miles,
> is it normal, then management consulted, no situation change. I told them
> forget it, put the car back together, and I was going to write Hyundai. I
> did get the oil changed though at least.
If you wore out brakes in 5300 miles, something is wrong. Aside from asking
for $287.50, did they mention a problem?
Brake wear is dependent on use, not miles, but I've never heard of them
going that fast unless they are severely abused or there is a mechanical
problem, such as not releasing the calipers properly. While the pads (wear
items) may be technically out of warranty, it there is a mechanical reason
that the brakes wore prematurely, that is probably covered. I'd sit down
again with the service manager and maybe the service manager's boss and see
if you can get a better response on the diagnostics. If they are just doing
a routine brake job under these circumstances, you are not getting proper
diagnostics, IMO.
Even though you did not use the parking brake often, that does not mean it
cannot cause a problem. It may have been mis-adjusted or sticking from the
factory. Was it checked? Also, non-use can cause it to stick too after
the cables get gunked up over time.
To have the pads replaced and not check and find the real cause is just a
waste of money. Finding the actual cause may also save you money if it
shows to be a defect in the system.
From my own experience, when I lived in the city, it was common to replace
brakes in 10,000 miles. After moving to a rural area, they can last me over
50,000 miles. I can drive 26 miles to work and hit the brakes just three or
four times as opposed to every block in the city.
Guest
Posts: n/a
Re: First problem - 2006 Elantra brakes
Bought new with less than 20 miles on it.
Only thing they told me was that the brakes had worn out, and wear items
and the labor were not covered after a year. Not sure what parts/repair
were involved, guess I should have asked, but was kind of in shock.
Parking brake used some, maybe twenty - thirty times 'ish'. Feels like a
parking brake should, no tension until a few clicks, then it grabs
nicely.
Can't imagine the mechanic etc. looking at almost brand new brakes that
are shot and not wondering about it, looking for a cause, etc., but they
aren't admitting to anything. I might try arguing with them one more
time, but since that didn't work the first time, might rather argue with
someone much higher up.
Only thing they told me was that the brakes had worn out, and wear items
and the labor were not covered after a year. Not sure what parts/repair
were involved, guess I should have asked, but was kind of in shock.
Parking brake used some, maybe twenty - thirty times 'ish'. Feels like a
parking brake should, no tension until a few clicks, then it grabs
nicely.
Can't imagine the mechanic etc. looking at almost brand new brakes that
are shot and not wondering about it, looking for a cause, etc., but they
aren't admitting to anything. I might try arguing with them one more
time, but since that didn't work the first time, might rather argue with
someone much higher up.
Guest
Posts: n/a
Re: First problem - 2006 Elantra brakes
unkadunk wrote:
> Bought new with less than 20 miles on it.
>
> Only thing they told me was that the brakes had worn out, and wear items
> and the labor were not covered after a year. Not sure what parts/repair
> were involved, guess I should have asked, but was kind of in shock.
>
> Parking brake used some, maybe twenty - thirty times 'ish'. Feels like a
> parking brake should, no tension until a few clicks, then it grabs
> nicely.
>
> Can't imagine the mechanic etc. looking at almost brand new brakes that
> are shot and not wondering about it, looking for a cause, etc., but they
> aren't admitting to anything. I might try arguing with them one more
> time, but since that didn't work the first time, might rather argue with
> someone much higher up.
>
>
>
>
If you do take it to another mechanic,
BRING the camera along!
Jim
> Bought new with less than 20 miles on it.
>
> Only thing they told me was that the brakes had worn out, and wear items
> and the labor were not covered after a year. Not sure what parts/repair
> were involved, guess I should have asked, but was kind of in shock.
>
> Parking brake used some, maybe twenty - thirty times 'ish'. Feels like a
> parking brake should, no tension until a few clicks, then it grabs
> nicely.
>
> Can't imagine the mechanic etc. looking at almost brand new brakes that
> are shot and not wondering about it, looking for a cause, etc., but they
> aren't admitting to anything. I might try arguing with them one more
> time, but since that didn't work the first time, might rather argue with
> someone much higher up.
>
>
>
>
If you do take it to another mechanic,
BRING the camera along!
Jim
Guest
Posts: n/a
Re: First problem - 2006 Elantra brakes
Elantras are prone to excessive rear brake pad wear (rear disk brake
models only), but your situation is extreme and indicates a problem. One
thing I found with my own car is that the pads fit too tightly in the
calipers and wouldn't return properly. To remove them, I literally had
to knock them out with a hammer and punch. When I replaced them at ~45k
miles, the new pads fit excessively tightly until I filed the ears on
the pads to fit the calipers. When you have your second mechanic look at
the car, mention this to him. I would also complain to Hyundai, as
they're likely to help you whether the 12 mo. warranty has expired or
not, since this indicates a problem that has existed on the car since it
was new and would have be covered under the warranty if you had known
about it.
models only), but your situation is extreme and indicates a problem. One
thing I found with my own car is that the pads fit too tightly in the
calipers and wouldn't return properly. To remove them, I literally had
to knock them out with a hammer and punch. When I replaced them at ~45k
miles, the new pads fit excessively tightly until I filed the ears on
the pads to fit the calipers. When you have your second mechanic look at
the car, mention this to him. I would also complain to Hyundai, as
they're likely to help you whether the 12 mo. warranty has expired or
not, since this indicates a problem that has existed on the car since it
was new and would have be covered under the warranty if you had known
about it.
Guest
Posts: n/a
Re: First problem - 2006 Elantra brakes
On Mon, 10 Mar 2008 16:27:56 -0500, unkadunk <unkadunk@nothere.com>
wrote:
>I will bring the camera, will try to get there tomorrow.
>
>Rears are drums.
The labor guide I looked at says 1.2 hrs to replace the rear brake
shoes.
Then the cost of the shoes need to be added in.
Old_Timer
wrote:
>I will bring the camera, will try to get there tomorrow.
>
>Rears are drums.
The labor guide I looked at says 1.2 hrs to replace the rear brake
shoes.
Then the cost of the shoes need to be added in.
Old_Timer
Guest
Posts: n/a
Re: First problem - 2006 Elantra brakes
I've seen two common problems cause rear brake wear on Elantras:
1. Binding parking brake cables. This seems to have lessened since about
the 2003 model.
2. Pad backing plates rusting on cars that are driven infrequently or
little. This causes them to stick in the calipers and wear.
Based on the model year and mileage, I'd suspect the issue is #2 above.
There are a couple ways to combat this issue. You could lubricate the
shims where the pads contact (with disc brake lube), but this won't
necessarily keep the rust away. Or you could grind the backing plates
just a little so they don't fit quite so tight in the shims, but this
could cause a tick or knock when the brakes are applied, or could cause
other noises to develop when braking.
--
Message posted using http://www.talkaboutautos.com/group/alt.autos.hyundai/
More information at http://www.talkaboutautos.com/faq.html
1. Binding parking brake cables. This seems to have lessened since about
the 2003 model.
2. Pad backing plates rusting on cars that are driven infrequently or
little. This causes them to stick in the calipers and wear.
Based on the model year and mileage, I'd suspect the issue is #2 above.
There are a couple ways to combat this issue. You could lubricate the
shims where the pads contact (with disc brake lube), but this won't
necessarily keep the rust away. Or you could grind the backing plates
just a little so they don't fit quite so tight in the shims, but this
could cause a tick or knock when the brakes are applied, or could cause
other noises to develop when braking.
--
Message posted using http://www.talkaboutautos.com/group/alt.autos.hyundai/
More information at http://www.talkaboutautos.com/faq.html
Guest
Posts: n/a
Re: First problem - 2006 Elantra brakes
"hyundaitech" <notpublic@not.public.com> wrote in
news:95a7e691286ae1a5922a968e40f857e7@localhost.ta lkaboutautos.com:
> I've seen two common problems cause rear brake wear on Elantras:
>
> 1. Binding parking brake cables. This seems to have lessened since
> about the 2003 model.
>
> 2. Pad backing plates rusting on cars that are driven infrequently or
> little. This causes them to stick in the calipers and wear.
>
> Based on the model year and mileage, I'd suspect the issue is #2
> above. There are a couple ways to combat this issue. You could
> lubricate the shims where the pads contact (with disc brake lube), but
> this won't necessarily keep the rust away. Or you could grind the
> backing plates just a little so they don't fit quite so tight in the
> shims, but this could cause a tick or knock when the brakes are
> applied, or could cause other noises to develop when braking.
>
Thanks for the info.
A pain in the butt/wallet for a 5300 mile car. I don't like to pay for
new and get used car problems.
news:95a7e691286ae1a5922a968e40f857e7@localhost.ta lkaboutautos.com:
> I've seen two common problems cause rear brake wear on Elantras:
>
> 1. Binding parking brake cables. This seems to have lessened since
> about the 2003 model.
>
> 2. Pad backing plates rusting on cars that are driven infrequently or
> little. This causes them to stick in the calipers and wear.
>
> Based on the model year and mileage, I'd suspect the issue is #2
> above. There are a couple ways to combat this issue. You could
> lubricate the shims where the pads contact (with disc brake lube), but
> this won't necessarily keep the rust away. Or you could grind the
> backing plates just a little so they don't fit quite so tight in the
> shims, but this could cause a tick or knock when the brakes are
> applied, or could cause other noises to develop when braking.
>
Thanks for the info.
A pain in the butt/wallet for a 5300 mile car. I don't like to pay for
new and get used car problems.
Guest
Posts: n/a
Re: First problem - 2006 Elantra brakes
On Tue, 11 Mar 2008 17:28:31 -0500, unkadunk <unkadunk@nothere.com>
wrote:
>Good news, after more phone calls to Hyundai of America I'm going to get
>the brake job under warranty. Thanks to all for your help!
Good news, but you should have been spared all that hassle.
wrote:
>Good news, after more phone calls to Hyundai of America I'm going to get
>the brake job under warranty. Thanks to all for your help!
Good news, but you should have been spared all that hassle.
Guest
Posts: n/a
Re: First problem - 2006 Elantra brakes
irwell wrote:
> On Tue, 11 Mar 2008 17:28:31 -0500, unkadunk <unkadunk@nothere.com>
> wrote:
>
>> Good news, after more phone calls to Hyundai of America I'm going to get
>> the brake job under warranty. Thanks to all for your help!
>
> Good news, but you should have been spared all that hassle.
Stuff happens. The point is that Hyundai is making it right.
> On Tue, 11 Mar 2008 17:28:31 -0500, unkadunk <unkadunk@nothere.com>
> wrote:
>
>> Good news, after more phone calls to Hyundai of America I'm going to get
>> the brake job under warranty. Thanks to all for your help!
>
> Good news, but you should have been spared all that hassle.
Stuff happens. The point is that Hyundai is making it right.
Guest
Posts: n/a
Re: First problem - 2006 Elantra brakes
On Tue, 11 Mar 2008 17:28:31 -0500, unkadunk <unkadunk@nothere.com>
wrote:
>Good news, after more phone calls to Hyundai of America I'm going to get
>the brake job under warranty. Thanks to all for your help!
What was the condition of the front brake pads?
If the front pads are nearly worn out too, it points to bad driving
habits.
If the front pads are almost like new, it points to a defect in the
rear brake system*. Your dealer should never have questioned it.
*Or,,, far less likely, the car was run with the parking brake
engaged, for whatever reason.
-
Bob
wrote:
>Good news, after more phone calls to Hyundai of America I'm going to get
>the brake job under warranty. Thanks to all for your help!
What was the condition of the front brake pads?
If the front pads are nearly worn out too, it points to bad driving
habits.
If the front pads are almost like new, it points to a defect in the
rear brake system*. Your dealer should never have questioned it.
*Or,,, far less likely, the car was run with the parking brake
engaged, for whatever reason.
-
Bob
Guest
Posts: n/a
Re: First problem - 2006 Elantra brakes
Bob Adkins <bob.adkins@gmail.com> wrote in
news:nrlit3dkdro206sj377q32vfjp1031lcr0@4ax.com:
> On Tue, 11 Mar 2008 17:28:31 -0500, unkadunk <unkadunk@nothere.com>
> wrote:
>
>>Good news, after more phone calls to Hyundai of America I'm going to
>>get the brake job under warranty. Thanks to all for your help!
>
> What was the condition of the front brake pads?
>
> If the front pads are nearly worn out too, it points to bad driving
> habits.
>
> If the front pads are almost like new, it points to a defect in the
> rear brake system*. Your dealer should never have questioned it.
>
>
> *Or,,, far less likely, the car was run with the parking brake
> engaged, for whatever reason.
> -
>
> Bob
>
Front pads are like new. My driving habits would be classified by other
drivers as 'get out of the way slowpoke'. Never found myself driving
with the parking brake on, and it always had a lot of 'free play' before
engaging, even when new.
Just got home with the new brakes and pulled on parking brake, very
little play, the brakes start engaging very quickly. Sounds like
sandpaper rubbing coming to a stop now, I'm gonna be real gentle and
hopefully they'll break in right.
Worst part was having to stare at/smell the Azera's in the showroom for
a couple of hours. Almost makes me want to say the heck with gas
mileage. Almost.
news:nrlit3dkdro206sj377q32vfjp1031lcr0@4ax.com:
> On Tue, 11 Mar 2008 17:28:31 -0500, unkadunk <unkadunk@nothere.com>
> wrote:
>
>>Good news, after more phone calls to Hyundai of America I'm going to
>>get the brake job under warranty. Thanks to all for your help!
>
> What was the condition of the front brake pads?
>
> If the front pads are nearly worn out too, it points to bad driving
> habits.
>
> If the front pads are almost like new, it points to a defect in the
> rear brake system*. Your dealer should never have questioned it.
>
>
> *Or,,, far less likely, the car was run with the parking brake
> engaged, for whatever reason.
> -
>
> Bob
>
Front pads are like new. My driving habits would be classified by other
drivers as 'get out of the way slowpoke'. Never found myself driving
with the parking brake on, and it always had a lot of 'free play' before
engaging, even when new.
Just got home with the new brakes and pulled on parking brake, very
little play, the brakes start engaging very quickly. Sounds like
sandpaper rubbing coming to a stop now, I'm gonna be real gentle and
hopefully they'll break in right.
Worst part was having to stare at/smell the Azera's in the showroom for
a couple of hours. Almost makes me want to say the heck with gas
mileage. Almost.