oil pan problem
Guest
Posts: n/a
Re: oil pan problem
Mike Marlow wrote:
> "Matt Whiting" <whiting@epix.net> wrote in message
> news:YdPJf.6321$lb.562261@news1.epix.net...
>
>>lenja wrote:
>>
>>
>>>I had a service at Hyundai dealership that included oil change. A
>>>service advicer called me and said that oil pan plug had damaged
>>>thread. He blamed a shop where I did last oil change. He suggested to
>>>retap and install larger plug. It was done and I was told that it
>>>worked.
>>>Next morning I found a big oil spill on my driveway. I went back to the
>>>dealer. The manager said that unfortunately the larger plug did not
>>>work and suggested to replace pan for about $350. Moreover the pan for
>>>my Elantra 99 is 'a special order' and I have to wait. Then I went to
>>>the local shop where the previous oil chage was done. The
>>>owner/mechanic said it was the dealer's fault. They just wanted to
>>>blame someone else. So, I got in the middle.
>>>
>>>Could anyone advice me what to do in this situation? I feel that I have
>>>to pay for the repair as it is impossible to prove which mechanic broke
>>>my oil pan.
>>>
>>
>>Not much you can do since you really can't prove who is lying. This is
>>the main reason I still do my own oil changes, even though it gets less
>>fun every year older that I get. Typically, a plug that is cross
>>threaded won't seal well and will leak at least a little. If you are
>>sure no oil was leaking prior to you visit to the last dealer, I'd
>>personally suspect they caused the damage rather than the first place.
>>However, I know of no way to tell for sure.
>>
>
>
> I'd head back to the dealer and tell them that there was *no* oil leak prior
> to their work on the car (assuming that really is the case). It would be
> quite obvious because any oil leak is going to leave telltale signs on the
> undercarriage.
Unfortunately, even lack of an oil leak doesn't implicate the last
dealer with any level of certainty. A cross threaded plug will often
leak, but a plug that was overtightened stripping the threads, often
won't leak. The person who put the plug in should have felt the threads
yield as it is a fairly obvious (and sickening!) feeling. However, the
drain plug will often remain very tight and nobody else will know until
they remove the plug and find that the threads from the oil pan come out
with it.
I'd probably try to get each dealer to split the cost of the repair as a
goodwill gesture since you can't be sure who did it. They may or may
not go for that, but it seems a reasonable compromise to me.
Matt
> "Matt Whiting" <whiting@epix.net> wrote in message
> news:YdPJf.6321$lb.562261@news1.epix.net...
>
>>lenja wrote:
>>
>>
>>>I had a service at Hyundai dealership that included oil change. A
>>>service advicer called me and said that oil pan plug had damaged
>>>thread. He blamed a shop where I did last oil change. He suggested to
>>>retap and install larger plug. It was done and I was told that it
>>>worked.
>>>Next morning I found a big oil spill on my driveway. I went back to the
>>>dealer. The manager said that unfortunately the larger plug did not
>>>work and suggested to replace pan for about $350. Moreover the pan for
>>>my Elantra 99 is 'a special order' and I have to wait. Then I went to
>>>the local shop where the previous oil chage was done. The
>>>owner/mechanic said it was the dealer's fault. They just wanted to
>>>blame someone else. So, I got in the middle.
>>>
>>>Could anyone advice me what to do in this situation? I feel that I have
>>>to pay for the repair as it is impossible to prove which mechanic broke
>>>my oil pan.
>>>
>>
>>Not much you can do since you really can't prove who is lying. This is
>>the main reason I still do my own oil changes, even though it gets less
>>fun every year older that I get. Typically, a plug that is cross
>>threaded won't seal well and will leak at least a little. If you are
>>sure no oil was leaking prior to you visit to the last dealer, I'd
>>personally suspect they caused the damage rather than the first place.
>>However, I know of no way to tell for sure.
>>
>
>
> I'd head back to the dealer and tell them that there was *no* oil leak prior
> to their work on the car (assuming that really is the case). It would be
> quite obvious because any oil leak is going to leave telltale signs on the
> undercarriage.
Unfortunately, even lack of an oil leak doesn't implicate the last
dealer with any level of certainty. A cross threaded plug will often
leak, but a plug that was overtightened stripping the threads, often
won't leak. The person who put the plug in should have felt the threads
yield as it is a fairly obvious (and sickening!) feeling. However, the
drain plug will often remain very tight and nobody else will know until
they remove the plug and find that the threads from the oil pan come out
with it.
I'd probably try to get each dealer to split the cost of the repair as a
goodwill gesture since you can't be sure who did it. They may or may
not go for that, but it seems a reasonable compromise to me.
Matt
Guest
Posts: n/a
Re: oil pan problem
"Matt Whiting" <whiting@epix.net> wrote in message
news:Ag%Jf.6339$lb.563728@news1.epix.net...
>
> Unfortunately, even lack of an oil leak doesn't implicate the last
> dealer with any level of certainty. A cross threaded plug will often
> leak, but a plug that was overtightened stripping the threads, often
> won't leak. The person who put the plug in should have felt the threads
> yield as it is a fairly obvious (and sickening!) feeling. However, the
> drain plug will often remain very tight and nobody else will know until
> they remove the plug and find that the threads from the oil pan come out
> with it.
Quite true Matt. One would think that if the dealer noticed this upon
removing the plug - and that would certainly be very noticable, that they
would immediately alert the owner and stop there. That's something of a
normal thing to do when on encounters something like that. I don't recall
now from the original post - did the OP say the dealer advised him that they
discovered this problem at the time, or was this an after the fact
revelation? I think in my most fair judgement, I'd say if the second dealer
did not stop immediately and notify the owner they had discovered a cross
threaded plug, that I'd be pretty suspicious of their claim that it was done
by someone before them. Any decent mechanic would stop right there with
that sort of problem.
>
> I'd probably try to get each dealer to split the cost of the repair as a
> goodwill gesture since you can't be sure who did it. They may or may
> not go for that, but it seems a reasonable compromise to me.
>
Yup.
--
-Mike-
mmarlowREMOVE@alltel.net
Guest
Posts: n/a
Re: oil pan problem
"Matt Whiting" <whiting@epix.net> wrote in message
news:Ag%Jf.6339$lb.563728@news1.epix.net...
>
> Unfortunately, even lack of an oil leak doesn't implicate the last
> dealer with any level of certainty. A cross threaded plug will often
> leak, but a plug that was overtightened stripping the threads, often
> won't leak. The person who put the plug in should have felt the threads
> yield as it is a fairly obvious (and sickening!) feeling. However, the
> drain plug will often remain very tight and nobody else will know until
> they remove the plug and find that the threads from the oil pan come out
> with it.
Quite true Matt. One would think that if the dealer noticed this upon
removing the plug - and that would certainly be very noticable, that they
would immediately alert the owner and stop there. That's something of a
normal thing to do when on encounters something like that. I don't recall
now from the original post - did the OP say the dealer advised him that they
discovered this problem at the time, or was this an after the fact
revelation? I think in my most fair judgement, I'd say if the second dealer
did not stop immediately and notify the owner they had discovered a cross
threaded plug, that I'd be pretty suspicious of their claim that it was done
by someone before them. Any decent mechanic would stop right there with
that sort of problem.
>
> I'd probably try to get each dealer to split the cost of the repair as a
> goodwill gesture since you can't be sure who did it. They may or may
> not go for that, but it seems a reasonable compromise to me.
>
Yup.
--
-Mike-
mmarlowREMOVE@alltel.net
Guest
Posts: n/a
Re: oil pan problem
"Matt Whiting" <whiting@epix.net> wrote in message
news:Ag%Jf.6339$lb.563728@news1.epix.net...
>
> Unfortunately, even lack of an oil leak doesn't implicate the last
> dealer with any level of certainty. A cross threaded plug will often
> leak, but a plug that was overtightened stripping the threads, often
> won't leak. The person who put the plug in should have felt the threads
> yield as it is a fairly obvious (and sickening!) feeling. However, the
> drain plug will often remain very tight and nobody else will know until
> they remove the plug and find that the threads from the oil pan come out
> with it.
Quite true Matt. One would think that if the dealer noticed this upon
removing the plug - and that would certainly be very noticable, that they
would immediately alert the owner and stop there. That's something of a
normal thing to do when on encounters something like that. I don't recall
now from the original post - did the OP say the dealer advised him that they
discovered this problem at the time, or was this an after the fact
revelation? I think in my most fair judgement, I'd say if the second dealer
did not stop immediately and notify the owner they had discovered a cross
threaded plug, that I'd be pretty suspicious of their claim that it was done
by someone before them. Any decent mechanic would stop right there with
that sort of problem.
>
> I'd probably try to get each dealer to split the cost of the repair as a
> goodwill gesture since you can't be sure who did it. They may or may
> not go for that, but it seems a reasonable compromise to me.
>
Yup.
--
-Mike-
mmarlowREMOVE@alltel.net
Guest
Posts: n/a
Re: oil pan problem
I also like Matt's compromise about splitting the cost but I am pretty
sure I will pay in full. I already spoke to both of them. None accepted
he could do that. Yes, I was alerted by the last dealer about the
problem. I was there during service and service adviser explained me
that they discovered the damage and they were going to put an oversized
plug to avoid costly pan replacement. I can't know who overtightened or
crossthreaded the plug. I really reluctant to blame the prior shop even
though they charge $50/hr compare to dealer's $108/hr. I have done a
lot of oil changes and other jobs at this local shop and never had any
problems with them. The owner looks reasonable and honest. I have to go
to dealers sometime because my car is still under 100,000/10years
warranty. Unfortunately my experience with dealers is much worse.
Actually I considered the last dealer as the best of 3 dealers closest
to my place. Now I am not so sure.
Lenja
sure I will pay in full. I already spoke to both of them. None accepted
he could do that. Yes, I was alerted by the last dealer about the
problem. I was there during service and service adviser explained me
that they discovered the damage and they were going to put an oversized
plug to avoid costly pan replacement. I can't know who overtightened or
crossthreaded the plug. I really reluctant to blame the prior shop even
though they charge $50/hr compare to dealer's $108/hr. I have done a
lot of oil changes and other jobs at this local shop and never had any
problems with them. The owner looks reasonable and honest. I have to go
to dealers sometime because my car is still under 100,000/10years
warranty. Unfortunately my experience with dealers is much worse.
Actually I considered the last dealer as the best of 3 dealers closest
to my place. Now I am not so sure.
Lenja
Guest
Posts: n/a
Re: oil pan problem
I also like Matt's compromise about splitting the cost but I am pretty
sure I will pay in full. I already spoke to both of them. None accepted
he could do that. Yes, I was alerted by the last dealer about the
problem. I was there during service and service adviser explained me
that they discovered the damage and they were going to put an oversized
plug to avoid costly pan replacement. I can't know who overtightened or
crossthreaded the plug. I really reluctant to blame the prior shop even
though they charge $50/hr compare to dealer's $108/hr. I have done a
lot of oil changes and other jobs at this local shop and never had any
problems with them. The owner looks reasonable and honest. I have to go
to dealers sometime because my car is still under 100,000/10years
warranty. Unfortunately my experience with dealers is much worse.
Actually I considered the last dealer as the best of 3 dealers closest
to my place. Now I am not so sure.
Lenja
sure I will pay in full. I already spoke to both of them. None accepted
he could do that. Yes, I was alerted by the last dealer about the
problem. I was there during service and service adviser explained me
that they discovered the damage and they were going to put an oversized
plug to avoid costly pan replacement. I can't know who overtightened or
crossthreaded the plug. I really reluctant to blame the prior shop even
though they charge $50/hr compare to dealer's $108/hr. I have done a
lot of oil changes and other jobs at this local shop and never had any
problems with them. The owner looks reasonable and honest. I have to go
to dealers sometime because my car is still under 100,000/10years
warranty. Unfortunately my experience with dealers is much worse.
Actually I considered the last dealer as the best of 3 dealers closest
to my place. Now I am not so sure.
Lenja
Guest
Posts: n/a
Re: oil pan problem
I also like Matt's compromise about splitting the cost but I am pretty
sure I will pay in full. I already spoke to both of them. None accepted
he could do that. Yes, I was alerted by the last dealer about the
problem. I was there during service and service adviser explained me
that they discovered the damage and they were going to put an oversized
plug to avoid costly pan replacement. I can't know who overtightened or
crossthreaded the plug. I really reluctant to blame the prior shop even
though they charge $50/hr compare to dealer's $108/hr. I have done a
lot of oil changes and other jobs at this local shop and never had any
problems with them. The owner looks reasonable and honest. I have to go
to dealers sometime because my car is still under 100,000/10years
warranty. Unfortunately my experience with dealers is much worse.
Actually I considered the last dealer as the best of 3 dealers closest
to my place. Now I am not so sure.
Lenja
sure I will pay in full. I already spoke to both of them. None accepted
he could do that. Yes, I was alerted by the last dealer about the
problem. I was there during service and service adviser explained me
that they discovered the damage and they were going to put an oversized
plug to avoid costly pan replacement. I can't know who overtightened or
crossthreaded the plug. I really reluctant to blame the prior shop even
though they charge $50/hr compare to dealer's $108/hr. I have done a
lot of oil changes and other jobs at this local shop and never had any
problems with them. The owner looks reasonable and honest. I have to go
to dealers sometime because my car is still under 100,000/10years
warranty. Unfortunately my experience with dealers is much worse.
Actually I considered the last dealer as the best of 3 dealers closest
to my place. Now I am not so sure.
Lenja
Guest
Posts: n/a
Re: oil pan problem
Unfortunately, there's no way to tell. You'll probably wind up eating the
entire cost. There are far too many monkeys out there who change oil and
have no idea that they don't have to tighten the drain plug enough to
hold
the whole car together.
entire cost. There are far too many monkeys out there who change oil and
have no idea that they don't have to tighten the drain plug enough to
hold
the whole car together.
Guest
Posts: n/a
Re: oil pan problem
Unfortunately, there's no way to tell. You'll probably wind up eating the
entire cost. There are far too many monkeys out there who change oil and
have no idea that they don't have to tighten the drain plug enough to
hold
the whole car together.
entire cost. There are far too many monkeys out there who change oil and
have no idea that they don't have to tighten the drain plug enough to
hold
the whole car together.
Guest
Posts: n/a
Re: oil pan problem
Unfortunately, there's no way to tell. You'll probably wind up eating the
entire cost. There are far too many monkeys out there who change oil and
have no idea that they don't have to tighten the drain plug enough to
hold
the whole car together.
entire cost. There are far too many monkeys out there who change oil and
have no idea that they don't have to tighten the drain plug enough to
hold
the whole car together.
Guest
Posts: n/a
Re: oil pan problem
I would go to a local auto wrecking yard and have them do a nationwide
search for a pan. Unless you're willing to pay the new price, this
could be a cost-effective solution. I've gotten some really good parts
and prices this way.
search for a pan. Unless you're willing to pay the new price, this
could be a cost-effective solution. I've gotten some really good parts
and prices this way.
Guest
Posts: n/a
Re: oil pan problem
I would go to a local auto wrecking yard and have them do a nationwide
search for a pan. Unless you're willing to pay the new price, this
could be a cost-effective solution. I've gotten some really good parts
and prices this way.
search for a pan. Unless you're willing to pay the new price, this
could be a cost-effective solution. I've gotten some really good parts
and prices this way.
Guest
Posts: n/a
Re: oil pan problem
I would go to a local auto wrecking yard and have them do a nationwide
search for a pan. Unless you're willing to pay the new price, this
could be a cost-effective solution. I've gotten some really good parts
and prices this way.
search for a pan. Unless you're willing to pay the new price, this
could be a cost-effective solution. I've gotten some really good parts
and prices this way.
Thread
Thread Starter
Forum
Replies
Last Post
Mike Salazar
Honda Mailing List
2
Jul 24, 2003 04:58 PM
Currently Active Users Viewing This Thread: 1 (0 members and 1 guests)



